郭 严, 康国政, 刘宇杰, 丁 俊. LZ50钢真应力控制下单轴棘轮行为的实验研究[J]. 工程力学, 2010, 27(9): 216-220,.
引用本文: 郭 严, 康国政, 刘宇杰, 丁 俊. LZ50钢真应力控制下单轴棘轮行为的实验研究[J]. 工程力学, 2010, 27(9): 216-220,.
GUO Yan, KANG Guo-zheng, LIU Yu-jie, DING Jun. EXPERIMENTAL STUDY ON UNIAXIAL RATCHETING OF LZ50 STEEL UNDER TRUE STRESS-CONTROLLED CYCLIC LOADING[J]. Engineering Mechanics, 2010, 27(9): 216-220,.
Citation: GUO Yan, KANG Guo-zheng, LIU Yu-jie, DING Jun. EXPERIMENTAL STUDY ON UNIAXIAL RATCHETING OF LZ50 STEEL UNDER TRUE STRESS-CONTROLLED CYCLIC LOADING[J]. Engineering Mechanics, 2010, 27(9): 216-220,.

LZ50钢真应力控制下单轴棘轮行为的实验研究

EXPERIMENTAL STUDY ON UNIAXIAL RATCHETING OF LZ50 STEEL UNDER TRUE STRESS-CONTROLLED CYCLIC LOADING

  • 摘要: 室温下对LZ50钢进行了系统的单轴应变控制和应力控制循环实验,揭示了材料的应变循环特性,讨论了平均应力、应力幅值、应力比及加载波形对材料棘轮行为的影响,重点比较和分析了传统的名义应力控制与改进的真应力控制模式下材料棘轮演变的异同点。结果表明:LZ50钢的变形行为没有明显的率相关性,并可视为循环稳定材料;真应力控制下产生的棘轮应变和棘轮应变率均小于名义应力控制下的结果,且两种控制方式对棘轮变形的影响与总的变形程度有关;棘轮应变随着平均应力和应力幅值的增大表现出单调上升的趋势,但不随应力比单调变化。

     

    Abstract: An experimental study was carried out on the cyclic deformation of LZ50 steel under a uniaxial strain and stress cycle at room temperature. The cyclic softening/hardening feature of LZ50 steel was first observed, and then the effects of mean stress, stress amplitude, stress-ratio and loading waveform on the ratcheting of the material were discussed. The main attention was paid to discern the different evolutions of the ratcheting presented in the material under the traditional nominal stress-controlled and improved the true stress-controlled cyclic loading. It is shown that: LZ50 steel presents no apparent time-dependent deformation, and can be simplified as a cyclically stable material. Both the ratcheting strain and ratcheting strain rate produced under the true stress-controlled cyclic loading are lower than those obtained from the nominal stress-controlled ones, and the extent of the difference greatly depends on the amount of total strain, and the difference was enlarged when the strain becomes larger and larger. The ratcheting strain increases monotonically with the increases of applied mean stress and stress amplitude, and decreases with the increase of stress ratio basically. However, it is not monotonic, and the most significant ratcheting occurs in the cycling with stress ratio of -0.659.

     

/

返回文章
返回