齐少轩, 任娟娟, 刘学毅. 桥上CRTSII型道岔板砂浆离缝影响特性研究[J]. 工程力学, 2015, 32(6): 124-132. DOI: 10.6052/j.issn.1000-4750.2013.12.1135
引用本文: 齐少轩, 任娟娟, 刘学毅. 桥上CRTSII型道岔板砂浆离缝影响特性研究[J]. 工程力学, 2015, 32(6): 124-132. DOI: 10.6052/j.issn.1000-4750.2013.12.1135
QI Shao-xuan, REN Juan-juan, LIU Xue-yi. INFLUENCE OF DEBONDING ON THE PERFORMANCE OF CRTSII SLAB TRACK TURNOUTS ON LARGE BRIDGES[J]. Engineering Mechanics, 2015, 32(6): 124-132. DOI: 10.6052/j.issn.1000-4750.2013.12.1135
Citation: QI Shao-xuan, REN Juan-juan, LIU Xue-yi. INFLUENCE OF DEBONDING ON THE PERFORMANCE OF CRTSII SLAB TRACK TURNOUTS ON LARGE BRIDGES[J]. Engineering Mechanics, 2015, 32(6): 124-132. DOI: 10.6052/j.issn.1000-4750.2013.12.1135

桥上CRTSII型道岔板砂浆离缝影响特性研究

INFLUENCE OF DEBONDING ON THE PERFORMANCE OF CRTSII SLAB TRACK TURNOUTS ON LARGE BRIDGES

  • 摘要: 水泥乳化沥青砂浆离缝是桥上纵连板式无砟轨道主要伤损型式之一。参考18号无砟道岔的结构形式,简化建立桥梁-纵连板式道岔垂向耦合静力和动力分析模型,应用有限单元法,计算分析了不同程度的道岔板下砂浆离缝对道岔结构变形及受力影响。研究表明,板下砂浆层发生离缝,对道岔板及钢轨的影响较底座板更明显。不同离缝形式对结构的影响程度不同,当离缝发生在板端时,道岔结构受力与变形最不利;发生在板中时,道岔板的翘曲位移变化不明显。依据计算结果得出板底砂浆离缝尺寸对道岔结构的影响规律,同时从无砟轨道稳定性角度出发,初步提出砂浆离缝尺寸限值,道岔板下砂浆离缝垂向高度低于1.8mm,沿线路纵向离缝长度小于0.7mm。

     

    Abstract: The debonding of emulsified cement asphalt mortar is one of the main damage types in longitudinally connected slab track turnouts of bridges. Based on the structure of No. 18 turnout, vertical-coupling models for longitudinally connected slab track turnouts are established for both static and dynamic analysis. Influences on the deformation and force of the track from different degrees of debonding underneath prefabricated slabs are analyzed using the finite element method. The study shows that debonding underneath prefabricated slabs has more significant impacts on prefabricated slabs and rails than on concrete bases. Different forms of debonding have different degrees of influence on the track. When the debonding occurs at the ends of the slab, the force and deformation of the track are greater. On the other hand, when the debonding occurs in the middle of the slab, the warping displacement of the slab is not obvious. Furthermore, the influence of the size of debonding on the track is analyzed, and critical dimensions of the debonding are proposed. The height of the debonding should be less than 1.8mm and the length less than 0.7m.

     

/

返回文章
返回